Scooter not getting fuel

The clone army is always ahead: counterfeit Galaxy Note 9 units already out in the wild
You can try applying a vacuum to the control port of the valve and see if the fuel flows. Replacing May 04, 2009 · I recently brought out my old 49cc 2 stroke stand up gas scooter after not running it for 2 years. For rubber lines, this will typically involve removing a hose clamp; other engines will require that you remove the line from the carburetor with a wrench. The fuel pressure gauge shows how much fuel is getting to the engine. The bike would start first time, I took it out for a little test ride but the fuel level was low. Ok, so you have the spark plug out of the motor, if the business end of the spark plug is completely caked with black crud, do yourself a favor and get a new spark plug right away. 7) to check for air If the scooter has been sitting for a few months with fuel in the carburetor, the fuel may have evaporated and left behind a sticky "gum" that will prevent the carburetor from working properly and which must be removed. So, to get your scooter to start with an electric starter, the following components need to work in harmony: The fuel valve; The battery; The spark plug If the fuel pump is electric, the 12-volt power may be shorted. 2014 TaoTao 50cc not getting gas to spark plug I purchased this scooter from another student off craigslist and he said that it ran fine until it sat in his house for at least 8 months. The Dawg Pound. The case of having a backfire when not getting enough fuel may not be as common as the other problems, but I have experienced it before. Moving on, the bike ran out of fuel so I put the bike back in the shed. No pump to worry about. When you are running you engine, if it feels like it is running out of fuel, or is wheezing and weak, it may be running to lean (not enough fuel. By sucking the thinnest one fuel comes out of the other thicker one. Take the top of the carb off (5 screws). They may be disappointed when they can't get the engine to fire. Place a rag over the end of the open fuel line. he said it is not getting fuel to the fuel filter. If your scooter does not have a rubber frame grommet for the fuel line, now is the perfect time to install one. They will greatly slow it down, but the gas will still go bad. I am pretty confident it was petrol and not diesel however if it was, the carb has been cleaned out and and its still not getting any petrol through. Sometimes the carb bowl is empty but there is enough fuel left in the accelerator pump passages to give a few squirts. Why is the engine bogging under acceleration? I recently managed to get the moped running properly, albeit for only a short time. The next day, I went and got £5 worth of fuel and poured it in. This is a major reason why engines don't start, especially if you drive your scooter on dirt roads. Fuel valve/petcock not in the on or reserve position. If there is a spark and the fuel is flowing into the filter, pull the fuel line off of carburetor and make sure that fuel is getting through the filter and into the carburetor. and wouldnt fire up 5. NO LIGHTS,? Read more. That hose is normal to have on a carburetor, it may have several, I believe it dumps excess fuel so that it doesn't flood in certain situations (not sure about the reason but, it is normal). com. If it turns, make sure the kill switch is "off" so you do not get a shock from the coil wire, and  Results 1 - 48 of 1252 Get the best deals on Scooter Fuel Pumps when you shop the largest online selection at eBay. Reply Reply Author. This is one Your browser does not currently recognize any of the video formats available. 1 product rating 1 product ratings - CARBURETOR AUTO CHOKE FOR HONDA HELIX CN250 CN 250 SCOOTER CARB 1986-2001 NEW Sym scooter will not start. Discussion. It is getting power and making a clicking sound but it is not doing ****. 4 Oct 2017 I have replaced the cylinder, piston, new head, new head gaskets, I am only getting 114 psi. . If you don't believe compression is an issue, like others have said, pull the fuel line off the carb and see if fuel is flowing. Quote. Do you have any gas in the tank,at least have way. I purchased it to fix it up as a hobby, but to also sell it for a profit afterwards. If not, there's a clog in the screens and you'll need to take the petcock off or disassemble and clean them out. Modern styling, top performance, and excellent fuel 20 Sep 2012 If your scooter wont idle or start check your fuel petcock. Statistically, the biggest problem for a scooter not starting is a gummed up carburetor/ blocked carb jets. One way to bypass all these components is to rig up a temporary gravity fed fuel flow directly to the carburetor. All motor scooters get great gas mileage and within a short period of time, your We do not require you to have a motorcycle license to purchase a scooter over  12 Apr 2020 Read this guide to figure out how to get your moped to run or are the small holes inside the carb (air and fuel passages). Ive replaced the spark plug, and it's making a spark. By doing this with the thicker connected correctly to the carb, the scooter started quickly. Fuel filter clogged with rust or dirt. You can replace the fuel filter they're cheap enough and can be found at a lawn mower type shop. Original Poster. Fuel flow problems can be caused by a clogged fuel filter, a clogged fuel line, a faulty fuel supply valve or a faulty fuel pump (on those scooters that use one). The fuel pump should run long enough to pressurize the fuel rail if this is what is keeping it from starting. Not getting far without one of these, son. If you are getting a spark and you are getting gas to the carburetor and the engine is  Fuel flow problems can be caused by a clogged fuel filter, a clogged fuel line, If the scooter starts, it must be getting some sort of spark, but the spark may be  Every engine needs Compression, good fuel, and good spark to run. 5 percent. When this happens, either the engine simply will not start, or it will not run without the choke on (this reduces the amount of air getting pulled into the engine, changing the fuel/air iv been having problems with my aerox, and still cannot get it started. Make sure you have fuel getting to the carburetor. It can usually be found within a few inches from the tank and is sometimes mounted onto the bottom of the tank. Disconnect the hose that connects the fuel pump to the carburetor. Mar 15, 2008 · Hi, I have a 50 cc Yamaha Vino Scooter. I have a 2008 TGB 49cc 101S off road sport scooter. now the bike is getting no fuel ( i can see a empty fuel filter. Gas will come shooting out the spark plug hole at high pressure. If the vacuum line is broken or cracked, no fuel. Feb 11, 2020 · Mostly, scooters have very simple gravity-fed carbs. For fuel injected engines: the injectors, like carburetor jets, can and do need cleaning. Pretty common, I've changed a couple. A hole in the fuel line on the tank side could also cause the fuel pump to suck air instead of fuel from the fuel tank. It sat for a year in storage and now won't start unless I spray some carb spray in the air cleaner. It just seems to not get fuel. Try this several times to make sure thats the problem. Fuel Flow. Expect prices of Honda models to go up by Rs 3,500 to Rs 5,000. 4L, which will cost you ride your scooter safely, as this will not only protect you, but reduce your fuel If you only need a vehicle to get around town, or to use infrequently, a moped  We get a lot of enquiries about scooters - sometimes from all over Australia about oil that is made for injection systems (that's oil injection, not fuel injection). If a large amount of gasoline does get into the engine oil; change the oil immediately upon fixing the problem that has allowed this to happen. After it runs a while, (2-3 miles) It quits like its fuel starved. Its much better then sucking on the hose and 50cc scooter not getting fuel Apr 23, 2013 21:14:31 GMT -5 . I replaced the petcock, but fuel is not going into the carburetor. Then it will take about 30min to get it started, but though it starts back up, when I give it gas, it will bog down like it's not getting any gas. Blocked Jets Jul 20, 2014 · No smell of fuel from the exhaust though. If you are getting a spark and you are getting gas to the carburetor and the engine is turning over on the starter OK, it's possible that the electrically operated automatic choke has failed. As for compression, I will have to go over with my compression tester later to be sure. Check the owner's manual to see how much pressure should be exerted when the pump is operating properly—anything less than that is a signal that your fuel pump needs immediate attention. I had already put new gas in it. Next,keep pumpping the primer until the fuel fills up the return line going back to your tank. Checking the Ignition System: The other major reason why an engine won't start is due to the engine not getting the right spark. I just bought in on Saturday from my boos. 2,331 posts. I ordered a new battery, spark plug &a OK so i took the ccarbs out of my Honda 1980 CB650 cleaned them out and put them back in, also in the process i installed a inline fuel filter. You should also inspect the fuel filter and see if it's clogged up with debris. It seems like it just won’t “turn over. If you're just trying to start the scooter then the RPMs that it's spinning at are quite low and doubt you'd get very much oil even with a ton of starting attempts. Usually there is a line with a filter at the end,make sure thats submerged. What can I do to fix this In particular, you want to clean all of the jets. [/quote] When I took off the fuel lines just a little fuel came out. The scooter could have one of a couple of potential problems. So…these tests. a. k. Make sure you are earthed against the metal of the bike, and the bike itself is earthed. Jan 12, 2009 · Next day shake the scooter before switching on the fuel, that's to mix the oil in the fuel if it's separated and sunk to the bottom (can happen with cheaper oils). Give Gift; Back to Top; Post by walk96 on Apr 23 Jul 25, 2018 · This video will show you how to possibly get your scooter back up and running if you're getting gas, have spark and compression. Try turning the ignition key to "on" for 5 or 10 seconds before you try a cold start. At this point many mechanics will open the rubber boot at the throttle body and; spray a small amount of starter fluid into the manifold; reinstall the boot and try to start the engine. Close the Too Little Fuel. This is going to be easy to spot and should be the largest washer in the area. and training modules to help technicians efficiently service ATVs, motorcycles, scooters and side by sides. ) If it stutters, and does not want to rev up all the way, it may be getting to much fuel (rich) When a two cycle engine is started cold, it will stutter a bit while warming up, then rev out to full speed. ii Vacuum lines:. I'll ask FI model experts to chime in with their own tips on how to work with injectors. Check the spark plug for sign of wear and tear. Select Post; Deselect Post; Link to Post; Member. ( +3 degree C) Spark is ok, spark plug is dry. Apr 21, 2016 · Clogged fuel tank vent There is a very small vent provided on the fuel tank of your motorcycle for the outlet to supply fuel continuously to the intake system. when renting scooters around the main beach strip or main drag  20 Mar 2015 Carburetor out of adjustment; Engine will not idle; Idle speed is excessive It is getting gas from the tank and if anyone knows how to help that  1 Sep 2011 There seems to be no shortage of "my scooter won't start" posts here on to consider the following: a scooter will not run without 3 things - fuel, air, If you are a mechanical person, get a Haynes manual or something and  10 Jun 2011 When kicking it over (the kick-start not the bike) it sometimes make a little If it was flooded you could kick it over a few times with the fuel shut off or you could Get an 8mm spanner and undo the 3 bolts holding the engine in  16 Jul 2015 If you have good spark and clean air, you're probably not getting fuel. We’ve seen it in the movies, we’ve read it in books, and that’s just how it is. Fuel valve/petcock clogged or diaphragm cracked, cut or torn 7. Scooter starts and idles fine but falls on its face when accelerating / scooter does not have good top end. Every truly crappy day begins with a car that won’t start. All these instructions can be used on earlier bikes without removing the tank. This sometimes happens when people take off their stock intake air box and replace it with cheap pod filters (which is what I did). Fuel cap or fuel tank not venting properly. If it is press the white button in, while this will reset the electric current. This is caused by a problem with the When you start the scooter it doesn't create enough vacuum at times to open this valve and feed fuel to the injector. You can get clear hose and llok for moisture. When my friend looked at it. If it kicks over and runs for a second then you have a fuel delivery problem in the carb or a posible fuel pump problem. kev b. a. Scooters Owned : 2003 Ruckus, 2006 Ruckus, 1983 Yamaha Beluga 80, 2007 Vespa LX 150, 2009 Yamaha BWS 125, 2008 Ruckus Hey guys,I just recently purchased a 2003 Yamaha Zuma (I believe 50cc) scooter. Please help. Fuel should pump out of the fuel line and stop when you let off the switch. 25 Mar 2020 renting scooter, getting fuel DO NOT GO TO JR PUMP!! 1 year ago. You can check the gauge while someone else is revving the car. DO NOT GET SPRAYED IN  The majority of our 50cc scooters have a fuel capacity of 5. The fact that your plug is a little moist suggests some mix is getting through, but its possible its not enough. If these get clogged, your scooter will not run well, if at all. If I suck on the vacuum line, it will flow. 3. Sep 20, 2012 · If your scooter wont idle or start check your fuel petcock. The fuel / air mixture screw should not be adjusted unless you are in a high elevation. It has been sitting awhile (about 2 years). Hit your starter switch. When engine is turned over, there’s no fuel going into the filter. ? I was going to mix fuel and oil to solve oil running out on floor problem, but appears 2cycle oil also lubes drivetrain. But no fuel is flowing to the carburetor. I have had the carb cleaned, Cleaned out the tank, put in a new fuel pump. 4. 120 months Saturday 18th July 2015 The plug has fuel on it but is not flooded, the exhaust port Apr 07, 2020 · Gas getting into oil becomes a cause for concern when the volume of gas exceeds 2. Now the unbolting process can begin. compression, I performed an external leak test with  16 Sep 2015 U can not SEE ANYTHING TO DAM DARK IT'S RIDICULOUS. Look in the tank to see if the lines are submerged. 2. Jun 05, 2013 · Hi, recently finished a scooter project. Someone said The Vespa fuel tap on early models are easily accessible by opening the carb flap below the seat near the fuel lever. Vacuum line to fuel valve cracked, broken, pinched, or missing 6. The pump will most likely look like the one pictured here. Start the bike and check how it runs now. Nov 12, 2018 · While tuning your 50cc moped, it’s best to look into the product’s fuel air-mix to see how it’s doing. The next destination of fuel from the tank in the scooter fuel system is the fuel pump. Cancel. ScootDawg's Scooter Forum a. Everything else works but I can't get gas to the spark plug. Reply 1. Nov 27, 2014 · Scooter started normal, but still would not take acceleration without bogging. If you squirt a little fuel into the plug hole & then get a sputter when you try to start it, then you know its a fuel delivery problem & you can isolate the issue to either fuel getting to, or from, the carburetor. so i put petrol down the reeds and spark plug hole and it revved to max rpm untili turned the key off. There may not even be signs of leaking, since a fuel line leak on the tank side would have to be above the fuel level for leakage to show. It will then start for I have a WR250F and it is not starting. He sucked on a vacuum line and it got fuel to the filter and then it ran. Check to make sure the circuit breaker is not popped on the battery pack. For the fuel line you will need to unclip the two safety clips which connect it to the carburetor, it should not leak fuel if the engine is not live. It seems worse when it is damp or has been sitting for a long time. And having sprayed the starter spray in there and not getting it to fire Pre mix the fresh fuel and determine if the carby reed valve is not stuck. Apr 01, 2018 · Pressing the starter button completes a circuit between the battery and the spark plug and also a circuit between the battery and the compressor, and turning the ignition opens the fuel valve. Why won't fuel go into my carburetor on my 50cc Chinese scooter? by Carl (Springtown, TX) I have a 50 CC Shenke Hornet scooter. Checking compression and checking for fuel from the petcock to the carb are the easiest first steps. ) the valve on the tank is not plugged neither is any of the lines buf for some reason the fuel will not pass through the filter. Make sure the spark plug boot isn't getting loose when it gets hot. Rules, New Member Introductions, and Forum Information. I bought a For the purpose of 2 stroke engine troubleshooting, we are going to keep the plug inspection simple. Autoplay When autoplay  If your scooter won't start it due to one of the above not being present. Some folks like using starter fluid as a check. 1. I take the vacuum line off and cut it and put an inline vacuum check valve or "one way" valve. If you are getting a spark and you are getting gas to the Fuel filters help reduce this problem by filtering particles from the fuel before they can reach small, easy-to-clog lines. It is definitely not the spark plug, and I already cleaned the pilot and main jet. It is a 2008 with only 240 miles on it. Things were looking up: I replaced the spark plug, cleaned out the exhaust, adjusted the idle / fuel screws, and even replaced the brakes (I can stop now!). I have GT5000 craftsman which is not geting fuel to the fuel pump, a new pump was installed n fuel filter n all fuel line were replaced. So here are some simple steps you can take to nip The easyest way to find out if you're not getting any fuel is to back out your spark plug, shoot some gas in on the valves, replace the spark plug and turn the engine over. The crankcase oil … read more My friend has a Honda ruckus, he called me because I'm supposed to be the mechanical genius but I have no idea what this, The fuel line from the fuel pump to the carburetor works, The fuel pump clicks but is not sucking any fuel, there's fuel in the fuel filter… But the pump still won't work. However, it will not start at all unless I put fuel into where the spark plug goes directly. Typical problems include hard starting, rough running, a need to adjust the carburetor during use to keep the engine from stalling, a need to rev the engine to ke Scooter – Page 2 < Its modern lines and easy handling make this a perfect scooter for getting around town. i beleive the oil and petrol isnt getting to the cylinder iv checked that both hoses have petrol and oil coming out when kickstarting , and they do. Hey Guys! Want to know why I am so strong-willed? Check out my e May 10, 2016 · Why is fuel not getting to spark plug on my yamaha raptor 50cc? Could be the carb float has come off and not letting any gas into the carb bowl? Could be a plug in the gas line or the inlet in the gas tank which usually has a screen on it is filthy and needs to be cleaned. It had old gas in it, but surprisingly started right up. Re: My scooter will not start!! Post by gerryh » Wed Feb 13, 2013 10:21 am Another way to do it is to pull off the spark plug lead, plug in the old spark plug, put the plug on the engine casing so you have a metal to metal contact and try starting it. I always had problems when I first got one because I'd give it too much throttle too soon and flood it. It stalled on my way to work on Sunday and it won't start. I don't think the cylinder is getting any gas anymore. This is one major problem if yours is bad. Usually after several tries I can get it started, but sometimes it just won’t get going. If you don't see gas the fuel valve may be faulty. If it starts by spraying starting fluid and dies as soon it runs out of starting fluid then this means there is no fuel getting to Jun 15, 2020 · The Thunder 50cc gas street legal scooter has a reliable 50cc engine that will keep you going at around 35MPH for over 100 miles using around 1. Apr 07, 2020 · Fuel Pump Testing – If the fuse is good and the circuit breaker is not tripped; then the engine is not getting fuel pressure. pod filters. An easy way to test that whole system is to pull the fuel line from the carb and aim it into something to catch the gas. In any case, there isn’t much you can do but call for help and be patient until it arrives. It should have another, much larger, hose from the carburetor providing fuel/air to the engine. After doing this, I realized by loosening the carb drain screw that no gas is even getting to the float bowl. With that said, if the plug looks wet, you are getting fuel. Is this the Jul 06, 2014 · If your scooter does not have any lights at all, this indicates there is no power getting to the mobility scooter. 50cc 2 stroke not getting fuel to the cylinder. modern fuel is the boiling point is lower, and you can get vapor lock even . After revving it high, it would keep shutting off, until I couldn't start it anymore. This is the standard fuel tank for vintage largeframe Vespa models VNB, VBB and VBC. Mar 23, 2020 · Scooter did not ignite whatsoever after lots of attempt. – check the jets! They are probably dirty. Mar 20, 2019 · Honda has not specified whether every two-wheeler in its range will get fuel injection. They just spray a quick  24 Jan 2007 In other words, it acts as if the engine is not getting enough fuel. Free shipping on many items | Browse  I cleaned carburetor and fuel filter but scooter still wouldn't start. I recently bought a used 2005 Yamaha Vino 125 cc scooter. not the outside. I have a Zhejiang Huawin magnum 150L scooter. Ethanol, methanol, and flex-fuel vehicles: The potential problems are the same whether the vehicle is running on pure gasoline or on gasoline mixed with alcohol: Either you’re out of fuel or the fuel pump or fuel injectors aren’t working properly. In most of the bikes in India, it is Mar 17, 2007 · zhongyu zy50qt 50cc scooter not getting fuel, oil fills cylinder and runs out on floor. I would like to try to get it running. I much prefer to know for sure that the bowl is full. I loosened the two hoses coming from some kind of valve below the tank. Switch on fuel & choke, hold throttle about a quarter turn then kick it over. Why am I not getting gas thru the carb to the cylinder head? If your engine will not start, make sure the scooter has gas in the gas tank and This will also cause problems with the fuel efficiently getting through the engine. Problem solved forever. The move will help its offerings comply with upcoming BSVI emission norms. When trying to start it in the morning you have to wait for the fuel rail to pressurize before the engine will fire. Prev Product 38 of 360 Next >> My scooter will not start. Save. Pros: + CARB approved (street legal) + perfect for all ages + fuss-free, electric start + gas powered scooter with good fuel economy + long, double-seat + double-seat for a smooth Disconnect the fuel line at the carburetor. Keep the tank out of the scooter, and loop the fuel line under the fuel control rod, and then up through the frame hole. See my guide here that discusses air boxes vs. Why does my 50cc Peace scooter bog down when I give it gas? by Jonathan (Baltimore, MD) When I kick start my Peace scooter, it will run, then cut off. It runs relatively well, but has a problem starting sometimes. It's supposed to operate when the engine is cold, but if it's stuck or burned out, the mixture will be weak and the scooter probably won't start. yesterday while rechecking valves for the hell of it i stripped a head bolt, will tap larger and replace soon, seemed to have a good hold despite noticeable spinning in place if i tried to tighten it so i left it for the time being, today i noticed some oil under the scoot dripping from near the exhaust, my first thought is that its a result of me screwing up the bolt but it doesnt look like The use of fuel additives, such as Sta-Bil or Sea Foam will not stop this process from happening. 5. This will clear up all the air thats trapped in the in-fuel line. Sucking on the line is one way to do this (but make sure it's the vacuum line, not the gas line if you try this!). The level of the fuel should be roughly 3/4" below the rim of the bowl. Fiddle around with the washer and see if it moves. You'll not only save lots of money but also skip the hassle of hauling your lawn mower, If the spark plug is wet with gas, it proves the engine is getting fuel. With the line attached at the top to the fuel tap, you need to feed it through the frame to the carb. Its much better then sucking on the hose and getting a mouth full of gas. Show less. 2 gallons of fuel. If it is and the engine will not start, the automatic choke could be inoperative. Later bikes after about 1960 or so have a fuel tap on the bottom of the tank, which unfortunately buried in the frame. I disconnect the fuel line to the pump n fuel filled up the filter. – Seminecis Sep 4 '13 at 22:26 If you are not getting fuel to the carb, something is failing along that path. You will also be able to see how the gas feeds out of your scooter gas tank and whether or not you have steady fuel supply coming out the hose. To do this, you’re going to open up the carburetor and find a washer that attaches itself to the fuel pipe. They may not hold pressure overnight. Fuel tank empty. in engines and bikes field (not a native english speaker and I'm not specialized in those fields). i Clogged carburetor . Take care not to damage the gasket or lose tiny parts. Make a gravity feed gas container (gas tank) and fuel line long enough to attach to the carburetor. ” It starts to rev up but then kind of sputters and dies. Try using starting fluid to aid the starting process, spray a little into the carburetor. A fuel pump is needed when gravity fuel flow is not practical. However, if the fuel filter becomes damaged or dirty, it can result in a clogged fuel line, causing a lean mixture and stalling under acceleratio